Efficiency of Sawdust as an Alternative Fuel to Replace Coal in Steam Power Plants

Penulis

  • Muhammad Facheruddin BJ Patria Artha University https://orcid.org/0009-0005-4503-994X
  • A. Besse Riyani Indah Industrial Engineering Faculty of Engineering Hasanuddin University
  • Gerard Antonini Duma Mechanical Engineering Faculty of Engineering Hasanuddin University

DOI:

https://doi.org/10.33387/protk.v12i1.9122

Kata Kunci:

Sawdust, Coal, Alternative fuels, Power generation, Thermal efficiency.

Abstrak

This study aims to test the effectiveness of sawdust as an alternative fuel to replace coal in a 50 MW power plant in an effort to reduce dependence on fossil fuels and have a negative impact on the environment. The use of coal in power plants produces high carbon emissions that contribute to climate change. Sawdust, as a by-product of the wood industry, is considered an environmentally friendly fuel because of its abundant availability and its calorific value close to coal. This study was conducted by measuring the calorific value, fuel consumption, and electrical energy output produced during power generation using sawdust compared to coal. The measurement results show that the calorific value of sawdust is 3900 kcal/kg, slightly higher than coal, which has 3878 kcal/kg. Although the fuel consumption of sawdust is almost equivalent to coal, the energy output produced by sawdust (47,090 kWh) is lower than coal (50,900 kWh). The thermal efficiency of sawdust is recorded at around 25.72%, slightly lower than coal, which has an efficiency of 27.76%. Despite its lower efficiency, these results suggest that sawdust can still be a viable alternative fuel, especially if emission reduction and desirability are priorities. This study shows that sawdust has the potential to be a more environmentally friendly energy source and support efforts to transition energy towards a more sustainable system.

Biografi Penulis

Muhammad Facheruddin BJ, Patria Artha University

Department of Mechanical Engineering, Faculty of Engineering and Informatics

Referensi

M. A. Destek, S. A. Sarkodie, and E. F. Asamoah, ‘Does biomass energy drive environmental sustainability? An SDG perspective for top five biomass consuming countries’, Biomass and Bioenergy, vol. 149, p. 106076, 2021, doi: https://doi.org/10.1016/j.biombioe.2021.106076.

M. A. Brown, A. Favero, V. M. Thomas, and A. Banboukian, ‘The economic and environmental performance of biomass as an “intermediate” resource for power production’, Util. Policy, vol. 58, pp. 52–62, 2019, doi: https://doi.org/10.1016/j.jup.2019.04.002.

T. P. da Costa, P. Quinteiro, L. A. da C. Tarelho, L. Arroja, and A. C. Dias, ‘Environmental impacts of forest biomass-to-energy conversion technologies: Grate furnace vs. fluidised bed furnace’, J. Clean. Prod., vol. 171, pp. 153–162, 2018, doi: https://doi.org/10.1016/j.jclepro.2017.09.287.

S. Tokarski, K. Głód, M. Ściążko, and J. Zuwała, ‘Comparative assessment of the energy effects of biomass combustion and co-firing in selected technologies’, Energy, vol. 92, pp. 24–32, 2015, doi: https://doi.org/10.1016/j.energy.2015.06.044.

A. Demirbas, ‘Combustion characteristics of different biomass fuels’, Prog. Energy Combust. Sci., vol. 30, no. 2, pp. 219–230, 2004, doi: https://doi.org/10.1016/j.pecs.2003.10.004.

J. O. Awulu, P. A. Omale, and J. A. Ameh, ‘Comparative analysis of calorific values of selected agricultural wastes’, Niger. J. Technol., vol. 37, no. 4, p. 1141, 2018, doi: 10.4314/njt.v37i4.38.

X. Zhang, K. Li, C. Zhang, and A. Wang, ‘Performance analysis of biomass gasification coupled with a coal-fired boiler system at various loads’, Waste Manag., vol. 105, pp. 84–91, 2020, doi: https://doi.org/10.1016/j.wasman.2020.01.039.

A. Paletto, S. Bernardi, E. Pieratti, F. Teston, and M. Romagnoli, ‘Assessment of environmental impact of biomass power plants to increase the social acceptance of renewable energy technologies’, Heliyon, vol. 5, no. 7, p. e02070, 2019, doi: https://doi.org/10.1016/j.heliyon.2019.e02070.

S. Zou et al., ‘Experimental research on an innovative sawdust biomass-based insulation material for buildings’, J. Clean. Prod., vol. 260, p. 121029, 2020, doi: https://doi.org/10.1016/j.jclepro.2020.121029.

A. A. Abdulhameed et al., ‘Experimental and environmental investigations of the impacts of wood sawdust on the performance of reinforced concrete composite beams’, Case Stud. Constr. Mater., vol. 19, p. e02550, 2023, doi: https://doi.org/10.1016/j.cscm.2023.e02550.

Y. Cheng and H. Li, ‘Utilization and development of biomass energy’, Energy Sci. Policy, vol. 1, no. 1, pp. 1–6, 2023, doi: 10.61187/esp.v1i1.12.

Unduhan

File Tambahan

Diterbitkan

2025-01-22

Cara Mengutip

BJ, M. F., Indah, A. B. R., & Duma, G. A. (2025). Efficiency of Sawdust as an Alternative Fuel to Replace Coal in Steam Power Plants. PROtek : Jurnal Ilmiah Teknik Elektro, 12(1), 32–35. https://doi.org/10.33387/protk.v12i1.9122

Terbitan

Vol 12 No 1 (2025): Protek : Jurnal Ilmiah Teknik Elektro

Bagian

PROtek : Jurnal Ilmiah Teknik Elektro

Lisensi

 

    1. Penulis menyimpan hak cipta dan memberikan jurnal hak penerbitan pertama naskah secara simultan dengan lisensi di bawah Creative Commons Attribution License yang mengizinkan orang lain untuk berbagi pekerjaan dengan sebuah pernyataan kepenulisan pekerjaan dan penerbitan awal di jurnal ini.

    1. Penulis bisa memasukkan ke dalam penyusunan kontraktual tambahan terpisah untuk distribusi non ekslusif versi kaya terbitan jurnal (contoh: mempostingnya ke repositori institusional atau menerbitkannya dalam sebuah buku), dengan pengakuan penerbitan awalnya di jurnal ini.

    1. Penulis diizinkan dan didorong untuk mem-posting karya mereka online (contoh: di repositori institusional atau di website mereka) sebelum dan selama proses penyerahan, karena dapat mengarahkan ke pertukaran produktif, seperti halnya sitiran yang lebih awal dan lebih hebat dari karya yang diterbitkan. (Lihat Efek Akses Terbuka).